Problem with 2006 trx450r Elec start

[WheelieMike]

Bike had no problems- I took it to Honda to get a HRC jet kit, Hot cam, K&N filter with sleeve (running without lid) and a full yoshi exhaust. Bike runs good when in motion but when I hit the gas while idle it just cuts off- Happened all through out the day causing me to abuse the electric start- Please tell me your thoughts! Thank you!

[Andy9933]

Bike had no problems- I took it to Honda to get a HRC jet kit, Hot cam, K&N filter with sleeve (running without lid) and a full yoshi exhaust. Bike runs good when in motion but when I hit the gas while idle it just cuts off- Happened all through out the day causing me to abuse the electric start- Please tell me your thoughts! Thank you!

Either the valves are set wrong or a jetting problem. Is it hard to start?

[WheelieMike]

Not hard to start at all, but dies as soon as I give it gas when not in gear- I brought it to Extreme Honda in Brandon where they did the work so i'll will post the resutls as soon as I find out the issue. Thank you very much for your response!

[Andy9933]

If its not hard to start it will be the carb:thumb:

[08trx450r]

I would check the fuel screw in the front of the carb towards the engine. The stock one is flush with the carb casting but if there was a aftermaket one in there you would deffinatly see it. My aftermarket one fell out once and it would do that.

[1BFC]

engine stall on throttle tip in is usually indicative of a lean condition. I have no idea how to adjust that carb though.

Since you had some performance parts put on the bike that specifically add better breathing capacity, I'd say it's a good place to start looking at the low speed side of the carb equation.

Good luck

[Baileygunns]

#55 leak jet...